Choose your preferred country site here
  • LightLight
  • WaterPump
  • PowerPower
  • SupportSupport

Troubleshooting - Lights

Lighting Tower Troubleshooting

Engine not starting

  • Check battery isolator is in ON position.
  • Ensure Emergency Stop (if fitted) is not engaged.
  • Check battery is charged. Charge or replace as required.
  • Check sufficient fuel in tank.
  • If ambient temperature is below 5 C, turn key to pre-heat before
    starting.
  • Check fuel tank for water contamination.
  • If tank has previously been emptied, prime by pumping fuel
    bulb
  • Check tower is level.

Engine Shutting Down

  • Check Engine fluid levels.
    Engine and alternator will be very hot after running. Allow to
    cool before checking fluid levels.
  • Check sufficient fuel in tank.

Lights Turning off

  • Check Shut down timer settings (if fitted).

 

 

All Lights fail to illuminate on start

  • Check Main circuit breaker is on.
  • Check all circuit breakers are on.
  • Lamps have been allowed to cool since last operation (15 mins).
  • Stop machine. Turn of main isolator switch to reset control
    panel and allow lights to cool down.

Individual Lamps Fail to Illuminate

  • Lamps have been allowed to cool since last operation (15 mins).
  • Circuit breakers are on.
  • Check lamp condition and replace if necessary.
    Light assemblies may be hot. Allow to cool completely before
    touching (15 mins).
  • Stop machine. Turn of main isolator switch to reset control
    panel and allow lights to cool down.

Circuit Breakers Trip

  • Turn engine off. Visually check for damaged cables. If no
    damage apparent, reset circuit breakers. Follow start up
    procedure.
    If fault persists after resetting, do not operate tower and call for
    service.

Hydraulic Pump and Motor does not Operate

  • Check battery isolator is in ON position.
  • Ensure Emergency Stop (if fitted) is not engaged.
  • Check Engine is running.
  • Check circuit breaker is on.

 

Perth
12 Hoskins Road, Landsdale
Tel: +61 (0)8 9302 7000

Brisbane
28 Gassman Drive, Yatala
Tel: +61 (0)7 3442 1122

Newcastle
42 Munibung Road, Cardiff
Tel: +61 (0)2 4954 1400

Melbourne
28–32 Ventura Pl, Dandenong
Tel: +61 (0)3 8795 6801